Monday, July 22, 2019

Happenstance


I must admit to playing favourites in my studio.  My 'go-to' loom has been the Spring. I like the way it involves all of me. Mind and body.  I can make choices on the fly and improvise.  The only drawback is the tie up which I have tried to improve for me physically by lifting up the loom and sitting on a stool to do the cords. With the loom only being 36 inches wide and light, it's not a big issue.

The Megado has no tie up per say.  The computer tells it what to lift and when.  Its very straight forward. The weaver simply treadles and throws the shuttle.  You watch the lines build into your chosen pattern and try to catch any irregularities within a pic or two.   All the thinking part is done when you are designing your draft. All the planning must be done in advance, or take time to revise away from the loom. 

Its a very different mindset and one I felt uncomfortable with..... but I think that's all changed. I'm feeling the love now.  

I had to get used to a different way of sitting and throwing. I also had to adjust to the fact that my left leg and knee are simply not strong enough to do its fair share of treadling so I have been building up strength slowly. The right leg does much of the work (for now).   Artificial joints don't move like a normal hip or knee and so you only gain 80-85% of your original mobility back.


Some thing was off with the loom though..... it was cranky and out of sorts. I would have to tighten up nuts and bolts after each towel woven.   It shouldn't be like this....


Here you can see what the screen I looks like when I'm weaving. This shows me at the end of a treadling repeat. I will reset the 'lag chain' again and carry on.  You can set it to endlessly loop and it will carry on, but I like to stop and change legs, wind another pirn and occasionally stretch.


Here's what it looks like on the loom. Its not a pattern you'll find anywhere but one that came by happenstance.


This is what I was originally weaving. A plaited or braided twill, but it wasn't very clearly defined. See the sample on the bottom in the picture below.


So I found another braided twill pattern and tried this one out:




This is the one is shown as the top sample and as you can see, it makes a big difference.  I must admit that being able to change things on the fly like this is kind of nice!

Roll the clock well ahead and I finally came back to the loom to get things moving again.  I decided to make start fresh with a new draft  and so started playing in Fiberworks again.


The green sample is one I tried and it was too muddled and so it went to the trash bin. Then I found this interesting pattern:  

Its meant to be woven as a point twill (see left hand side of draft) but my threading is a straight draw (see the right hand side of draft).  I tested it out as shown in the turquoise sample pictured above.   I liked it!   I might even try this one again in the point twill version in the future.

So I wove off 7 towels, using up some of my cottolin stash for weft.  The warp is 8/2 unmercerised cotton in a natural beige or bone colour.  Sett is 24 epi.


So six full sized towels, final measurements approximately 19 inches x 29 inches.  There is one shorter one that I'm calling a table square.

 I wove to 34 inches on the loom, they relaxed to 33 inches and came out of the wash (before hemming) to 30 inches!   That's a lot of loss in the length. They also lost in width as well so its a good thing I make them large to begin with!   I did a very simple rolled hem and hand stitched.   A good press in the Singer steam press and they are finally done.





Thick and thirsty !   Two are being gifted right away 😊


Meanwhile....I'm happy to say that the Megado is finally being reloaded with 6.5 yards of tencel for scarves.  I'll be sleying the reed this afternoon. We did a total rebuild of the back of the loom and shifted some carriage bolts that were in the wrong locations. Suddenly the loom is behaving and we will have a much better time of it from here on in!


The Spring has an 8 yard cotton warp waiting to be threaded for another towel warp.   So who gets my attention now?   Its a coin toss every day now....  I admire their differences and love them both.

At long last.  💖


4 comments:

Lynnette said...

What a good read. I am so happy that your Megado has begun to work for you. I sure look forward to see where you can go with all of those shafts! Holy cow, the sky really is the limit!

thistle rose weaving said...

Susan, I love the fact that you got to experiment with drafts on your Megado. The resulting towels are just lovely.

thistle rose weaving said...

Love the new towels

Pat said...

Love the towels, such pretty colours too!